What is Silage?
Silage is high-moisture fodder preserved through fermentation in the absence of air. These are fodders that would deteriorate in quality if allowed to dry.
Silage can be made from grasses, fodder sorghum, green oats, green maize or Napier grass.
An ideal crop for silage making should;
i) Contain an adequate level of fermentable sugars in the form of water-soluble carbohydrates
ii) Have dry matter content in the fresh crop above 20%
iii) Possess a physical structure that will allow it to compact readily in the silo after harvesting
Crops not fulfilling these requirements may require pre-treatment such as:
i) Field wilting, to reduce moisture
ii) Fine chopping, generally 20–25 mm preferred to allow compaction
iii) Use of additives, to increase soluble carbohydrates
Harvesting stages
Napier grass should be harvested at about 1 meter when protein content is about 10%. Maize and sorghum should be harvested at dough stage that is when the grain is milky.
The grains will provide water-soluble sugars and molasses is not necessary when ensiling. When ensiling nappier grass, molasses should be added to increase the sugar content
To improve silage quality, poultry waste and legumes like lucerne and desmodium may be mixed with the material being ensiled to increase the level of crude protein.
Types of silos
A silo is an airtight place or receptacle for preserving green feed for future feeding on the farm.
Silos can be either underground or above ground, the qualification 40 being that the silo must allow compaction and be air tight
Five types are described here: tube, pit, above-ground, trench and tower.
Tube silage
Silage can be made in large plastic sacks or tubes. The plastic must have no holes to ensure no air enters. This is popularly referred to as tube silage.
Silage can also be made in pits that are dug vertically into the ground and then filled and compacted with the silage material.
An above-ground silos made on slightly slanted ground. The material is compacted and covered with a polythene sheet and a layer of soil is added at the top.
When finished, it should be dome-shaped so that it does not allow water to settle at the top but rather collect at the sides and drain away down the slope.
The trench silos
The trench silos an adaptation of the pit silo, which has long been in use. It is much cheaper to construct than a pit silo.
Construction is done on sloping land. A trench is dug and then filled with silage material. This method is ideal for large-scale farms where the tractor is used.
Drainage from rain is also controlled to avoid spoiling the silage.
Tower silos
Tower silos are cylindrical and made above-ground. They are 10m or more in height and 3m or more in diameter.
Tower silos containing silage are usually unloaded from the top of the pile. An advantage of tower silos is that the silage
tends to pack well due to its own weight, except for the top few feet.
Qualities of good silage
Well-prepared silage is bright or light yellow-green, has a smell similar to vinegar and has a firm texture.
Bad silage tends to smell similar to rancid butter or ammonia.
Natural microorganisms turn the sugars in the plant material or any added as molasses into weak acids, which then act as a preservative.
The result is a sweet-smelling, moist feed that cattle like to eat once they get used to it.
Storage and feeding
Tube silage should be stored under shade, for example in a store. Rodents like rats that could tear the tube need to be controlled.
When feeding, open the tube and scoop a layer and remember to re-tie without trapping air inside.
When feeding from the pit, scoop in layers and cover after removing the day’s ration, making sure the pit is air tight.
Drainage from the top should be guided to avoid rainwater draining into the pit.